TSIB TC002-07 ALL LEXUS MODELS; DRIVESHAFT ASSEMBLY REPLACEMENT
The purpose of this bulletin is to provide information regarding anti–corrosion grease that is present on replacement driveshaft assemblies. It is important to remove this grease prior to installing the hub nut to prevent overtightening. This also applies when reusing an old driveshaft ...
- TSIB AC001-05 2004 LEXUS GX 470; NOISE FROM REAR A/C UNIT
Some GX 470 owners may experience a crackling/static type sound from the right rearHVAC assembly. This procedure provides a method to improve this condition.
- TSIB AU001-06 ALL LEXUS MODELS; AUDIO QUICK REFERENCE GUIDE
Lexus has developed a quick reference guide to be used by technicians when troubleshooting typical audio system concerns. This guide is intended only as a supplement to the diagnostics already available in the Repair Manual.
- TSIB NV001-06 2004-2007 ALL LEXUS MODELS; FRONT SEAT SQUEAK NOISE
Some customers may experience a squeak noise due to contact between the seat track locating pin(s) and the floor pan location hole(s). The following procedure describes the repair method to correct this condition.
- TSIB AC003-06 2003-2006 LEXUS GX; A/C PERFORMANCE IMPROVEMENT
Some GX 470 customers may experience a low cooling effect from the A/C system when driving in high temperature areas. This TSIB provides a procedure to improve this condition.
- TSIB BO010-06 (Lexus GX470) REAR DOOR WEATHERSTRIP DETACHING
Some customers may notice that the rear door opening weatherstrip pulls away from the body either at the top of the opening or on the side by the door striker. Service parts have been modified to correct this condition.
- TSIB SS001-06 FLUID PRESSURE PUMP UPGRADE
The couplers on the Fluid Pressure Pump Kit (SST P/N 00002–12000–01) have been upgraded to ensure proper fit when servicing and/or repairing the Kinetic Dynamic Suspension System (KDSS). A hydraulic anaerobic sealer will also be included in the Fluid Pressure Pump Upgrade Kit to sea ...
- TSIB PG016-02 2003-2006 LEXUS GX; MOON ROOF INITIALIZATION
This bulletin outlines the initialization procedure for the moon roof on the 2003 – 2006 model year GX 470. If the battery has been disconnected, the moon roof ECU will not be able to detect and memorize the moon roof positions, resulting in the following features being inoperative. One- ...
- TSIB SS002-07 2003 - 2007 MODELS UPPER/LOWER WINDSHIELD TICK NOISE
If a creak, tick, or rattle noise is heard at the top or bottom of the windshield, the source of the noise may be the two windshield stoppers bonded to the top of the windshield or the windshield retainers bonded to the lower edge of the windshield. This bulletin provides the recommended repai ...
- [2004 GX470] Tire Pressure Monitoring System (TPMS) light will not turn off. I've checked all tire pressures (including the spare) and also toggled the button on the bottom of the dash.
Tire pressure sensors are not registered to the vehicle or bad sensor. Dealer will have to break down the tires and register the sensors to the car. Paid $125.00 for all 5 wheels to have them registered. Light disappeared.
- Lexus Trouble Codes OBD and OBDII
Lexus Code Retrieval Accessing Diagnostic Trouble Codes 96 & later are OBD2 systems The check engine warning light will come on when the ignition switch is turned On and the engine is not running. When the engine is started, the check engine warning light should go off. If light remains on, the ...
- TSIB PG001-07 2004-2008 ALL LEXUS MODELS; DIRECT-TYPE TIRE PRESSURE WARNING SYSTEM DIAGNOSTIC TIPS
The Tire Pressure Warning System (TPWS) monitors the difference in tire pressure in all four or five tires (if the vehicle is equipped with a full-size spare tire) through radio wave signals from a tire pressure valve/sensor mounted in each wheel.
- TSIB AC005-04 ALL LEXUS MODELS; SENSOR INSPECTION FOR AIR CONDITIONING SYSTEM
This service bulletin contains inspection procedures to more precisely confirm proper operation of the following temperature sensors of the air conditioning system. Follow the procedures in this service bulletin when inspecting these sensors. These contents will be reflected in future repair m ...
- How do I install Xenon/HID bulbs into my GX470?
The answer to this question comes from ""Tony"" on ClubLexus.com. Here's the link to the thread: http://www.clublexus.com/forums/showthread.php?t=114059 In case the link doesn't work, the complete article is attached.
- Reset Maintenance Required Light
1. With your car OFF, place your key in the ignition and turn to ""On"". Do not start the car. 2. Find the odometer button and press until it reads the total odometer setting, (not the Trip A or Trip B setting). 3. Turn the key to OFF. 4. Place your finger back on the odometer button, press and ...
- Rear door/hatch stay is showing signs of corrosion and rust.
**TECHNICIAN NOTES** REAR HATCH DOOR STAY VERY RUSTY. FINISH CAME OFF. REPLACED DOOR STAY AND HARDWARE. 642991 REPLACED REAR DOOR STAY 1 65896-60020 CAP, COVER TOP SET B 1 65903-60010 BRACKET SUB-ASSY, BA 1 69609-60020 LINK SUB-ASSY, BACK 1 68091-60010 RAIL SUB-ASSY, BACK PART #: 69609-60020 CO ...
- What Generation Navigation is in my Lexus?
Shown below is a list of Lexus models shown with the generation of navigation technology equipped in each. Generation 1 1998-2000 GS300 1998-2000 GS400 1998-2000 LS400 1999-2000 LX470 Generation 2/3 2001-2005 GS300 2001-2005 GS400 2001-2003 LS430 2002-2003 ES300/330 2001-2004 RX300/330 2001-20 ...
- I feel a pulsating type of vibration during idle with and without the AC unit on.
**TECHNICIAN NOTES** PLEASE NOTE: The 4.7 liter does not have a EGR system for emissions. Exhaust valves are designed to stay slightly open during the intake stroke in cylinder to burn off excess exhaust gasses. This makes engine feel a little rougher running compared to engines with VVTI. VVTI ...
- How do I install an iPod adapter or interface to my GX470?
This website has it very nicely detailed and it's also available as a download via a PDF file. http://www.emba42.com/lexus/
- Driver's side window is inoperable after using remote down feature. Then is also inoperable from inside ""Auto"" switch.
**TECHNICIAN NOTES** L/F window inoperable with remote feature. Open circuit, replaced master switch. 675161 Power Window Master Switch Assembly 1 84040-60073 Master Switch Assembly PART#: 84040-60073 COUNT: 1 FOUND THAT MASTER SWITCH ON DRIVERS DOOR WOULD LOSE MEMORY FOR JAM PROTECTION AND WOU ...
